ROAD TO 400HP - Turbo Subaru BRZ/FRS/GT86 - Part 5 of 6 (Full Blown Walbro 485 Fuel Pump Install) скачать в хорошем качестве

ROAD TO 400HP - Turbo Subaru BRZ/FRS/GT86 - Part 5 of 6 (Full Blown Walbro 485 Fuel Pump Install)

ROAD TO 400HP - Turbo Subaru BRZ/FRS/GT86 - Part 5 of 6 (Full Blown Walbro 485 Fuel Pump Install) Fuel pump upgrade is another fuel upgraded needed when running high boost (10psi+) with ethanol. I strongly recommend the Full Blown Walbro 485 Fuel Pump install (not sponsored, lol). There is a lot of positive feedback in the community with this fuel pump and can't go wrong with choosing it. Like most of my fuel upgrades, they are overkill components, but it is better to have more legroom than maxing out smaller injectors or fuel pumps. Like always, reliability(engine wise) is also my priority, so choosing the best product for important components is always a must. Also a quick and easy install of the Verus fuel starvation door. Usually, at high loads of g fuel tend to cut off and come out the basket which is where this door would come in. It is a straight plug and plays which would help alleviate the starvation problem. Enjoy the high(ish) power BRZ. Instagram: @BRZSer ~~~Steps / Check List~~~ Remove fuel pump fuse (for safety and just incase things) Remove 10mm bolt-on the rear driver seat and remove the seat Open fuel door to relieve fuel tank pressure Use a flat head screwdriver to take off the plate (note adhesive very sticky) Take of electrical connectors Take off the first black line Use a rubber mallet and flathead screwdriver to remove fuel pump reservoir cap Don't use any power tools, metal hammers, or anything that could cause sparks or else "gg" car or possibly life too Take off retaining clips by spring-loaded strut thingy Remove 3 clips holding it in place, unclip them at the same time Take it apart and remove two of the black and grey electrical connectors Take off 3-piece clip for more room to work on Remove the fuel filter from the bottom of fuel pump casing by unclipping 3 clips Use something to poke fuel pump-out Make sure to remove o-ring from the old fuel pump Place back the new fuel pump aligning the o-ring and make sure it sits nicely Cut the regulator clip from old fuel filter clip Install the regulator clip Use new aluminum fuel pump bracket, and tighten it with hex keys Place the new fuel filter that is supplied with the kit Install Verusstarvation door kit into place making sure it's facing the right direction Put the fuel pump things back in the basket Cut the old fuel pump connection to be installed onto the new fuel pump butt connectors The red wire goes with light blue, white black goes with grey Reconnect the wiring onto the fuel pump reservoir cap Remove the fuel tank cap rubber seal Install provided full-blown fuel pump kit spacer with o-ring (Use the best method possible since this is important Install the black rubber gasket back into the basket cap Reinstall the cap of the basket, compress and reinstall the c-clip Reinstall the gas basket back into the fuel tank using the reverse step of taking it out. Reinstall fuel pump fuse Tune car (if injectors were changed) Cross fingers and check for leaks/problems and hope there's none Enjoy them extra horses. ~~~Parts used in this install~~~ Full Blown FRS/BRZ/GT86 Walbro 485 Fuel Pump Kit http://fullblownmotorsports.com/full-... Verus Fuel Starvation Door For FR-S/ BRZ/GT86 https://www.verus-engineering.com/pro...  ~~~MODS On The 2013 SUBARU BRZ~~~ Engine: SBD500X v3 Turbo Kit Tune by HRI Tuning Running 8/10/12 psi on e85 (380~400 crank HP @12 psi) Mishimoto Oil Cooler Radium Dual Oil Catch Can STI PCV Valve & Check Valve Fumoto Oil Drain Valve - F108S GrimmSpeed Boost Controller Moto - East Flex Fuel Kit Injector Dynamics ID1000(cc) Port Injectors Full BlownWalbro 485 Fuel Pump Verus Fuel Basket Starvation Door Exhaust: ISR 2.5" Over-pipe 1320 Dual Resonated Front pipe Ark Grip Catback Exhaust Transmission: ACT SB7-XTSS With Streetlight Flywheel Verus Clutch fork & pivot Individual Parts Racing (IRP) Short Shifter Wheels & Tires: SSR - GTV02 18x9.5 +40 Nitto nt555 G2 245/40/18r Suspension: Stock lol Exterior: DuckTail - Ikon MotorSports Anjoshi Bumper Quick Release